Biogas desulfurization with limewater is a relatively low-cost desulfurization technology. In the process of using limewater as desulfurizer, only low-cost CaO is consumed. The waste is a mixture of CaSO4, CaSO3 and smoke and dust. Water can be permanently recycled in the system.
脫硫過程比較復雜，下面小編就給大家詳細的介紹一下：
The process of desulfurization is rather complicated. The following section will give you a detailed introduction:
1、煙氣中的SO2與水H2O生成亞硫酸H2SO3。
1. H2SO3 sulfite is formed from SO2 in flue gas and H2O in water.
2、煙氣中的SO2與噴淋水中的Ca(OH)2反應生成CaSO3沉淀。
2. CO2 in flue gas reacts with Ca(OH)2 in spray water to form CaSO3 precipitation.
3、煙氣中的CO2與噴淋水中的Ca(OH)2反應生成CaCO3沉淀。
3. CO2 in flue gas reacts with Ca(OH)2 in spray water to form CaCO3 precipitation.
4、在循環水噴淋過程中CaCO3被H2SO3置換成CaSO3。
4. CaCO3 is replaced by H2SO3 in the spraying process of circulating water.
5、在循環水噴淋過程中CaSO3被煙氣中的氧O2成CaSO4沉淀。
5. CaSO3 is precipitated into CaSO4 by oxygen in flue gas during the spraying process of circulating water.
In order to reduce the consumption of CaO (lime), the PH value of spraying water should be kept between 5 and 6 in the spraying water cycle. When the PH value of spraying water drops below 5.5 due to the increasing concentration of H2SO3, water lime should be stirred to make the PH value of spraying water reach above 8.
注意事項：
Matters needing attention:
1、每班(8小時)攪拌石灰漿2-3次。
1. Mix lime slurry 2-3 times per shift (8 hours).
2、每班清理除塵器底部沉淀物1-2次。
2. Clean the bottom sediment of the dust collector 1-2 times per shift.
這種脫硫技術的缺點是: 管道及噴咀易堵塞。
The disadvantage of this desulfurization technology is that the pipeline and nozzle are easily blocked.
Well, today's wonderful content will be introduced to you here first! The editorial board of biogas desulfurization regularly organizes and publishes some industry information for you. Welcome to collect our website: http://www.chinaktws.com.
企業二維碼
2019-08-19
魯公網安備37011202000764號號